|
TIS Documents
Document Information
The majority of these documents relate to the S52 M Roadster / M Coupe
given their inherent similarities. But given the commonality of
these models with the Z3 and other BMW models (E36, E30), a lot of the documents are not exclusive to the Roadster or
Coupe.
There are several types of documents within the TIS system which
you will encounter while reviewing or researching this page:
- AZD = Tightening Torques
- RA = Repair Information
- SI = Service Information Bulletin
- SWZ = Special Tool
- TD = Technical Data
On occasion, you will find references to other documents within the
one your reviewing. In the actual TIS system, these references
will link you to the document in question. Since I have no way
to pull out all these links and recreate them within these posted
PDF's, you've got to use your brain a little. I'll explain...
As an example, you may see an outlined block
of text on a page that contains information referring to a particular section,
or an
actual document number. If the text is a number like "11 13 000"
then it's an actual document and would be in section 11 (engine), sub
section 13 (oil sump), etc. If box just contains text,
then try to decipher what section the information will be contained
based on which area the document your reviewing originated.
When it comes to a Technical Data reference
in a document, or to tightening something , this
will be an "AZD" document (see above).
Most likely the AZD document is going to in the same section,
or maybe the "parent" section of the part of the
car in which you're working.
For example, you might be changing the
transmission fluid, which is covered in section
00 Maintenance and General Data, but the AZD
information is in section 23 Manual
Transmission.
What you will usually see is something like
"refer to Technical Data 23 00 4AZ". This
means the information is contained in document
"AZD 23 00" section 4AZ. When ever I've
run across any technical references I've done my
best to make sure to include the technical
document in it's appropriate location.
More often than not, if the box simply states
"refer to technical data", it's going to be a TD
document in the same section.
On occasion though, you may find references to
technical or torque data in these link boxes
that is not contained in the same section.
Based on how the text is worded in the section
you're reading, you can usually figure out where
to look. An example would be, an RA
document about removing a wheel and finding
lubricant on the hub. The RA document
refers you to a brake removal document to check
for leaking fluid, but does not indicate which
one. Go look in the brake section and
you'll find the document you need.
Sections denoted with an
&
are considered complete in as much as TIS has repair documents
listed for the M Roadster / Coupe. When going through the TIS
information for these completed section, I've included done my best
to include any referenced AZD or TD documents. Later on I will
be going through and ensuring none were missed and adding them as
necessary.
Lastly... some legal stuff:
The use of this information constitutes acceptance for use in an AS
IS condition. There are NO warranties, implied or otherwise, with
regard to this information or its use. Any use of this information is
at the user's risk. In no event shall I be held liable for any damages
whatsoever arising out of or in connection with the use or spread of
this information.
These documents are in PDF format and require
Adobe
Acrobat Reader.
This page is always under construction
- 00 Maintenance and General Data
- 11 Engine
- 12 Cylinder head with cover
- 13 Oil sump
- 14 Housing cover
- 21 Crankshaft with bearing
- 22 Flywheel
- 23 Vibration damper
- 24 Connecting rod with bearing
- 25 Piston with rings and pin
- 28 V-Ribbed belt with tension / deflection element
- 31 Camshaft
- 34 Valves with springs
- 36 Variable camshaft timing
- 40 Oil supply
- 41 Oil pump with filter and drive
- 42 Oil Filter and Lines
- 51 Water pump with drive
- 52 Fan
- 53 Thermostat and connections
- 61 Intake manifold
- 62 Exhaust manifold
- 78 Emission control / oxygen sensor
- 12 Engine electrical system
- 00 Troubleshooting
- 12 Ignition wires, spark plugs
- 13 Ignition coil
- 14 Electric switching or control units
- 31 Alternator with drive and mounting
- 32 Regulator
- 41 Starter with mounting
- 42 Starter leads
- 63 Switches with relays
- 13 Fuel system
- 00 Checking / setting engine / emission
- 31 Fuel pump with drive and line
- 32 Fuel filter
- 41 Speed governor
- 51 Injector pump, regulator, mixture regulator
- 53 Injection nozzle and lines
- 61 Electronic control unit
- 62 Sensor for control unit
- 64 Start valves
- 71 Intake silencer
- 72 Air cleaner
- 90 Carbon canister ventilation
- 16 Fuel supply system
- 00 Fuel pick-up, cleaning system
- 01 (No description)
- 11 Fuel tank with mounting
- 12 Fuel transfer, sensor for gauge
- 13 Fuel ventilation
- 14 Fuel pump
- 17 Cooling system
- 00 Coolant, checking coolant system
- 10 Radiator, expansion tank, pipes
- 11 Engine radiator with attachment
- 40 Auxiliary electrical fan
- 18 Exhaust system
- 00 Exhaust system complete
- 12 Mufflers, petrol
- 32 Exhaust catalytic converter
- 21 Clutch
- 00 Maintenance and inspections
- 21 Clutch with driving disc
- 51 Clutch release lever
- 52 Clutch operation (hydraulic)
- 90 Troubleshooting
- 23 Manual transmission
- 00 Transmission assembly
- 01 (No description)
- 12 Seals
- 21 Transmission shafts
- 23 Synchromesh
- 30 Gearshift in transmission
- 25 Gear shift mechanism
&
- 11 Center shift, manual transmission
- 26 Propeller shaft (drive shaft)
&
- General
- 11 Propeller shaft assembly
- 12 Center console assembly
- 90 Troubleshooting
- 31 Front axle
- 00 General
- 10 Front axel suspension
- 11 Front sub-frame
- 12 Struts with rubber mounts
- 21 Wheel bearings and stub axel
- 31 Spring strut
- 32 Shock absorber
- 33 Spring with suspension
- 35 Stabilizer bar
- 90 Troubleshooting
- 32 Steering and wheel alignment
- 00 Electronic chassis alignment
- 11 Mechanical steering gear
- 13 Steering gear with servo unit
- 21 Steering arms, tie rods, steering dampener
- 31 Steering column
- 32 Steering lock
- 33 Steering wheel
- 34 Steering wheel for air bag
- 41 Pump and oil supply
- 90 Troubleshooting
- 33 Rear axle
&
- 00 General
- 10 Final drive
- 11 Final drive with cover
- 12 Crown gear and pinion with bearings
- 13 (No Description)
- 14 Locking differential with bearings
- 17 Final drive mounting
- 21 Output shafts
- 31 Rear sub-frame
- 32 Control arms and struts
- 33 Axel mounting
- 41 Wheel bearings
- 52 Shock absorber
- 53 Springs with suspension
- 55 Stabilizer bar
- 90 Troubleshooting
- 34 Brakes
- 00 Brake test and bleeding
- 10 (No Description)
- 11 Front wheel brakes
- 21 Rear wheel brakes
- 31 Master brake cylinder
- 32 Brake lines
- 33 Brake booster
- 41 Parking brake
- 50 Slip control systems (ABS, ASC)
- 51 Mechanical / hydraulic components
- 52 Electronic components
- 35 Pedals
&
- 00 General
- 11 Pedal mounting block
- 21 Brake pedal with linkage
- 31 Clutch pedal with linkage
- 41 Kick-down
- 36 Wheels and tires &
- 10 Wheels
- 12 Tires
- 13 Mounting
- 41 Body
- 00 Body
- 11 Support members
- 12 Luggage compartment floor
- 14 Wheel wells
- 21 Side frame and door pillars
- 22 Roof frame
- 31 Roof outer skin
- 32 Dash cowl
- 33 Front trim panel
- 34 Rear trim panel
- 35 Side panels
- 51 Front side doors
- 61 Front lid
- 62 Rear lid
- 51 Body equipment
- 00 General
- 11 Front bumper
- 12 Rear bumper
-
AZD 51 12 Rear Bumper
-
RA 51 12 000 Removing and installing complete rear bumper (Z3
Roadster, M Roadster, Z3 Coupe, M Coupe)
-
RA 51 12 001 Replacing rear bumper (Z3 roadster, M roadster)
-
RA 51 12 742 Replacing a shock absorber for bumper, rear (Z3
Roadster, M Roadster, Z3 Coupe, M Coupe)
-
RA 51 12 801 Replacing bracket for bumper, rear left or right
(Z3 Roadster, M Roadster, Z3 Coupe, M Coupe)
- 13 Trim, covers, handle trim
- 14 BMW emblems, model emblems
- 16 Mirrors, covers, ashtrays, shelves, trays
- 17 Lids
- 21 Front door locks, handles, fittings
- 23 Hood latch, locks
- 26 Central locking system
- 31 Front and rear window
- 32 Front manually operated windows
- 33 Front electrically operated windows
- 33 Rear electrically operated windows
- 41 Front door trim panel with arm rest
- 43 Side covering with armrests
- 44 Roof trim panel
- 45 Instrument cluster trim panel
- 46 Parcel shelf trim panel / roller sun blind
- 47 Floor, luggage, engine compartment trim panels
- 71 Loose body parts
- 52 Seats
- 54 Hood
- 10 Sunroof
- 21 Hardtop
- 31 Convertible top linkage/operation
- 34 Motor-operated convertible top
- 61 Rollover bar, fixed
- 61 General electrical system
- 00 Troubleshooting
- 12 Auxiliary cables
- 13 Connectors, terminals, fuse box
- 20 Battery
- 21 Battery / vapor separator
- 31 Switch
- 35 Modules
- 36 Relay
- 61 Windscreen wipers
- 62 Rear screen wiper
- 62 Instrument &
- 10 (No Description)
- 11 Instrument cluster
- 13 Clock and similar
- 16 Sensor for vehicle electrical system
- 21 Instrument panel
- 99 Lamps for instruments
- 63 Lights
- 10 Lamp settings
- 12 Headlights
- 14 Clearance and side marker lamps
- 17 Fog lights, auxiliary lights
- 21 Rear light cluster
- 25 Brake lights
- 26 License plate lights
- 31 Interior lights
- 99 Light bulbs
-
64 Heating and air conditioning
- 01 (No Description)
- 11 Heater with operation
- 50 Air conditioning system
- 51 AC housing/evaporator, switching elements
- 53 Condenser and dryer with lines
- 65 Special equipment
- 11 Radio mono
- 12 Radio stereo, amplifier
- 13 Loudspeaker and cover
- 20 Antenna
- 21 Manual antenna
- 77 Diagnostic unit
- 81 On-board computer
- 99 Troubleshooting
-
71 Equipment / accessories for engine / chassis
- 72 Equipment and accessories for body
- 03 (No Description)
- 11 Seat belts
- 12 Airbag generator / airbag unit for passenger
- 84 Communications systems
- 86 Trailer
- 10 Loading platform
- 21 Hood
Home | My Car | Links | Misc. Photos | TIS Documents | Z3 FAQ | Feedback
|
